['Waste']
['Hazardous Waste']
12/02/2024
Copyright 2024 J. J. Keller & Associate, Inc. For re-use options please contact copyright@jjkeller.com or call 800-558-5011.
...
Standard Number:1910.1200(b)(2); 1910.1200(b)(6)(i); 1910.1200(b)(6)(xi); 1910.1200(c); 1910.1200(h)(1)-(3); 1910.1200(h)(3)(ii)-(iii); 1910.1096(i)(2)
December 23, 2014
Dr. Leslie A. Walleigh
P.O. Box 229
West Rockport, Maine 04865
Dear Dr. Walleigh:
Thank you for your letter to the Occupational Safety and Health Administration’s (OSHA) Directorate of Enforcement Programs. You asked a specific question regarding whether or not OSHA’s Hazard Communication standard (HCS), 29 CFR 1910.1200, is applicable to waste products that are exempt from regulation under the U.S. Environmental Protection Agency’s (EPA) Resource Conservation and Recovery Act (RCRA). This letter constitutes OSHA’s interpretation of only the requirements discussed and may not be applicable to any questions not delineated within your original correspondence. Your paraphrased scenario and questions are below, followed by our response. Please excuse the delay in our response.
Scenario: You provide occupational medicine consultations to truck drivers employed to haul drilling wastes, flowback water, and produced waters off of unconventional gas extraction well sites. Wastes from unconventional gas extraction sites, such as those using the hydraulic fracturing process, are well-recognized to contain benzene, toluene, ethylbenzene, xylenes, and radioactive materials found naturally in the underlying formation. Flowback waters may also contain the same hazardous chemicals, such as silica sand, that were used in the fluids injected for the hydraulic fracturing (or fracking) process.
Questions: Is OSHA’s HCS applicable to waste products that are exempt by RCRA? Would an employer of the truck drivers hauling wastes and produced waters have some responsibility to know what the potential hazards of exposure are to these waste products, and to appropriately educate their employees?
Response: OSHA’s HCS applies to hazardous chemicals known to be present in the workplace in such a manner that employees may be exposed under normal conditions of use or in a foreseeable emergency (see 29 CFR 1910.1200(b)(2)). However, the HCS does not apply to “[a]ny hazardous waste as such term is defined by the Solid Waste Disposal Act, as amended by the Resource Conservation and Recovery Act of 1976, as amended (42 U.S.C. 6901 et seq.), when subject to regulations issued under that Act by the Environmental Protection Agency” (see 29 CFR 1910.1200(b)(6)(i)).
The RCRA defines “hazardous waste” as “solid waste, or combination of solid wastes, which because of its quantity, concentration, or physical, chemical, or infectious characteristics may - (A) cause, or significantly contribute to an increase in mortality or an increase in serious irreversible, or incapacitating reversible, illness; or (B) pose a substantial present or potential hazard to human health or the environment when improperly treated, stored, transported, or disposed of, or otherwise managed” (42 U.S.C. §6903(5)). “Solid waste” is defined under the RCRA as garbage, refuse, sludge, “and other discarded material” (42 U.S.C. §6903(27)).
EPA’s regulations implementing RCRA provide that certain solid wastes are not hazardous wastes, including “[d]rilling fluids, produced waters, and other wastes associated with the exploration, development, or production of crude oil, natural gas or geothermal energy” (40 CFR §261.4(b)(5)). EPA also issued guidance in October 2002 explaining that while gas exploration and production (E&P) wastes (e.g., flowback or produced waters) are exempt from RCRA Subtitle C hazardous waste regulations, these waste types may fall under the control of state regulations, RCRA Subtitle D solid waste regulations, and other federal regulations. See Exemption of Oil and Gas Production Wastes from Federal Hazardous Waste Regulations (EPA 530-K-01-004), available at: http://www.epa.gov/epawaste/nonhaz/industrial/special/oil/oil-gas.pdf*. This guidance document also includes lists of both exempt and non-exempt waste products. 1
When waste does not meet the definition of “hazardous waste” under the RCRA regulations, it is covered by the HCS if it meets the standard’s definition of “hazardous chemical” and if it does not fall under any of the other HCS exemptions. The HCS defines “hazardous chemical” as “any chemical which is classified as a physical hazard or health hazard, a simple asphyxiant, or combustible dust, pyrophoric gas, or hazard not otherwise classified” (29 CFR 1910.1200(c)). The HCS requires employers to provide employees with effective information and training on hazardous chemicals in their work area (see 29 CFR 1910.1200(h)(1)-(3)). Among the training an employer must provide is training on the physical, health, simple asphyxiation, combustible dust, pyrophoric gas hazards, and hazards not otherwise classified, and the measures employees can take to protect themselves from these hazards (see 29 CFR 1910.1200(h)(3)(ii)-(iii)).
You also mentioned that truck drivers who haul drilling wastes from gas extraction well sites are concerned about potential exposure to radioactive materials. Ionizing radiation is exempt from the HCS (see 29 CFR 1910.1200(b)(6)(xi)). However, employers with employees working in a radiation area must comply with OSHA’s Ionizing Radiation standard, 29 CFR 1910.1096, including instructing workers on precautions to minimize exposure (see 1910.1096(i)(2)).
OSHA has developed additional resources regarding the identification and control of other health hazards encountered in the oil and gas production and hydraulic fracturing processes. These resources include: OSHA Hazard Information Bulletin: Potential Health Hazards Associated with Handling Pipe used in Oil and Gas Production (available at: https://www.osha.gov/dts/hib/hib_data/hib19890126.html) and Hydraulic Fracturing and Flowback Hazards Other than Respirable Silica (available at: http://www.osha.gov/Publications/OSHA3763.pdf*).
Thank you for your interest in occupational safety and health. We hope you find this information helpful. OSHA requirements are set by statute, standards, and regulations. Our interpretation letters explain these requirements and how they apply to particular circumstances, but they cannot create additional employer obligations. This letter constitutes OSHA’s interpretation of the requirements discussed. Note that our enforcement guidance may be affected by changes to OSHA rules. Also, from time to time we update our guidance in response to new information. To keep apprised of such developments, you can consult OSHA’s website at http://www.osha.gov. If you have any further questions, please feel free to contact the Office of Health Enforcement at (202) 693-2190.
Sincerely,
Thomas Galassi, Director
Directorate of Enforcement Programs
1 For more information regarding the products EPA considered to be hazardous waste under the RCRA regulations, please visit: http://waste.supportportal.com/link/portal/23002/23023/Article/22091/What-is-a-RCRA-hazardous-waste
READ MORESHOW LESS
['Waste']
['Hazardous Waste']
Load More
J. J. Keller is the trusted source for DOT / Transportation, OSHA / Workplace Safety, Human Resources, Construction Safety and Hazmat / Hazardous Materials regulation compliance products and services. J. J. Keller helps you increase safety awareness, reduce risk, follow best practices, improve safety training, and stay current with changing regulations.
Copyright 2024 J. J. Keller & Associate, Inc. For re-use options please contact copyright@jjkeller.com or call 800-558-5011.